The paper bulids a countercurrent multi-effect drying process model which can be expressed as a linear programming(LP) problem with the minimum total energy consumption as target function. Based on the model it can be...The paper bulids a countercurrent multi-effect drying process model which can be expressed as a linear programming(LP) problem with the minimum total energy consumption as target function. Based on the model it can be conventient to solve the heat load , degree of drying and other drying parameters of each effect. And it realizes the mathematical simulation an analysis of multi-effect drying process. Such process not only reuses the secondary steam but also utilizes the high energy grade. Drying silica sand using 1-effect drying to 5-effect drying is presented as an example. The energy consumption and energy saving rate are compared by using co-current multi-effect drying and countercurrent multi-effect drying. As a summary, the countercurrent multi-effect drying is better than co-current drying. Considered the equipment investment and energy conservation, the study also concluded that the countercurrent 4-effect drying is the optimum selection, and it can save 57.6% energy compared to countercurrent 1-effect drying.展开更多
Artificial neural network has unique advantages for massively parallel processing, distributed storage capacity and self-learning ability. The paper mainly constructs neural network identifier and neural network contr...Artificial neural network has unique advantages for massively parallel processing, distributed storage capacity and self-learning ability. The paper mainly constructs neural network identifier and neural network controller for system identification and control on temperature and hmnidity of heating and drying system of materials. And the paper introduces the structure and principles of neural network, and focuses on analyzing learning algorithm, training algorithm and limitation of the most widely applied multi-layer feed-forward neural network （ BP network） , based on which the paper proposes introducing momentum to improve BP network.展开更多
Solar drying systems are becoming a popular alternative to traditional energy-based drying systems for agricultural products due to their effectiveness and reduced fuel consumption.Although the efficiency of solar dry...Solar drying systems are becoming a popular alternative to traditional energy-based drying systems for agricultural products due to their effectiveness and reduced fuel consumption.Although the efficiency of solar drying systems has been thoroughly investigated,their sustainability has not been studied enough.This study aims to fill that gap by conducting a life-cycle assessment of two new solar drying systems built in Udaipur,Rajasthan,India.The environmental implications of an innovative cylindrical solar-assisted drying system and a phase-change material-based solar drying system were evaluated using cradle-to-gate life-cycle analysis.The study uses the ReCiPe 2016 endpoints(H)technique to calculate various aspects such as midpoint,endpoint,single score,normalization result,and network diagram for phase-change material-based solar drying and cylindrical solar-assisted drying.Results show that phase-change material-based solar drying has an average of 40%more impact on the environment than cylindrical solar-assisted drying,with a high impact found in human non-carcinogenic toxicity,mainly due to the production of phase-change materials.However,cylindrical solar-assisted drying system crossover phase-change material based solar drying in terms of its impact on human carcinogenic toxicity and fossil resource scarcity.The contribution to global warming of phase-change material-based solar drying is 13.7%more than that of cylindrical solar-assisted drying.The endpoint characterization indicates that phase-change material-based solar drying exceeds in terms of human health(40%)and ecosystem(37.04%),whereas cylindrical solar-assisted drying surpasses phase-change material-based solar drying in terms of impacts on resources,at 14%.The early drying in phase-change material-based solar drying makes up for its higher impact than that in cylindrical solar-assisted drying,which takes 3 hours longer to dry.This study offers guidance and methods for making the best choice of solar-powered dryers.展开更多
Côte d’Ivoire has been the world’s leading producer of cocoa beans for several decades. Apart from this production performance, the quality of the beans, which are mainly exported to the major chocolate-making ...Côte d’Ivoire has been the world’s leading producer of cocoa beans for several decades. Apart from this production performance, the quality of the beans, which are mainly exported to the major chocolate-making countries, presents a quality problem to the point of suffering a discount on the international market. One of these quality problems is the content of ochratoxin A, a mycotoxin produced by fungi. Finally, to verify the level of contamination in beans produced in Côte d’Ivoire, a study was carried out. It consisted of collecting information on fermentation and drying times (The two major post-harvest operations) and collecting beans, which were analyzed by electrophoresis using the High Performance Liquid Chromatography (HPLC) method. The results obtained show ochratoxin A contents of between 0.05 µg/kg and 0.17 µg/kg. The general level of contamination is therefore very low and below the tolerable limit which is 2 µg/kg. In addition, the correlative study between the fermentation and drying times of the beans revealed no significant influence (p < 0.01) of the duration of these operations on the level of ochratoxin A contamination. Major contamination can occur after post-harvest activities carried out by producers. This is certainly due to the development of fungi responsible for the production of ochratoxin A during the period of storage and marketing of cocoa beans in conditions of high humidity in storage enclosures. Producers need to be made more aware of the need to ensure that cocoa beans are properly dried and stored in dry areas to avoid moisture build-up, which is a source of mould growth and ochratoxin A production.展开更多
The effect of a storage system on drying time and estimation of drying parameters of cocoa beans using an indirect solar dryer with a sensible heat energy storage system (stones which act as both absorber and heat sto...The effect of a storage system on drying time and estimation of drying parameters of cocoa beans using an indirect solar dryer with a sensible heat energy storage system (stones which act as both absorber and heat storage media) is the main subject of this article. This dryer, which uses stones as storage material and is made of wood and plywood, was used to dry a quantity of 5 kg of fermented cocoa beans. The drying parameters for the drying curves and the drying efficiency of cocoa beans were established and studied. The drying curves were modelled from semi-empirical models. The results showed that the moisture of cocoa beans decreased from 60% to 7% in wet basis. With a solar collector and drying efficiency of 40% and 34%, respectively. And this with a maximum average difference temperature between the drying air and the ambient temperature of 13.25˚C day or night. The best concordances are obtained with R2 values of 0.9983, 0.9843, 0.9813 and 0.9837 respectively from the models of Hii, Jena and Das, Demir et al. and Alibas.展开更多
Strip-till(ST),including straw mulching in the inter-row and localized fertilization in the intra-row,is a conservation tillage system for improving soil quality and crop growth.However,the yield advantage of maize un...Strip-till(ST),including straw mulching in the inter-row and localized fertilization in the intra-row,is a conservation tillage system for improving soil quality and crop growth.However,the yield advantage of maize under ST compared to conventional tillage(CT)remains unstable,and the strategies to increase maize yield under ST are unclear.This study aims to understand the physiological mechanism underlining maize yield formation under ST by comparing two maize cultivars,DKM753 and DK517,with contrasting yield performance in ST versus CT systems.Compared to CT,ST resulted in a 4.5%yield increase for DKM753 but a 5.6%decrease for DK517.These yield differences were primarily attributed to variations in grain number per ear(GN).During the rapid growth stage(V14-R3),i.e.,two weeks before and after silking,DKM753 showed a 6.7%increase in maximum growth rate(V_(max))and a 6.3%increase in average growth rate(V)under ST,whereas DK517 exhibited decline of 8.5%in V_(max) and 12.3%in V.Significant positive correlations are observed between V_(max) and V with GN under ST(R^(2)=0.79 and R^(2)=0.90,respectively).Enhanced dry matter accumulation in DKM753 under ST was attributed to increased leaf expansion rates,contributing to a larger photosynthate source.The straw mulching and localized nitrogen fertilization increased root-zone nitrogen availability at silking in ST compared to CT.DKM753 had a greater root system which made better use of the soil N and lead to an increased leaf nitrogen accumulation by 14.9%under ST.It is concluded that maize yield under the strip-till system is determined by grain number per ear,which can be increased by increasing nitrogen accumulation,plant growth,and ear development around silking stage.A sound root system can efficiently utilize soil nitrogen resources under the strip-till system,increasing plant nitrogen accumulation and thereby promoting plant growth.展开更多
Alternate wetting and drying(AWD)system,in which water has been reduced by approximately 35%with an increased occurrence of beneficial arbuscular mycorrhizal(AM)symbiosis and no negative impact on rice yield,was propo...Alternate wetting and drying(AWD)system,in which water has been reduced by approximately 35%with an increased occurrence of beneficial arbuscular mycorrhizal(AM)symbiosis and no negative impact on rice yield,was proposed to utilize water and nutrients more sustainable.In this study,we selected six rice cultivars(Centauro,Loto,Selenio,Vialone nano,JSendra and Puntal)grown under AWD conditions,and investigated their responsiveness to AM colonization and how they select diverse AM taxa.In order to investigate root-associated AM fungus communities,molecular cloning-Sanger sequencing on small subunit rDNA data were obtained from five out of the six rice cultivars and compared with Next Generation Sequencing(NGS)data,which were previously obtained in Vialone nano.The results showed that all the cultivars were responsive to AM colonization with the development of AM symbiotic structures,even if with differences in the colonization and arbuscule abundance in the root systems.We identified 16 virtual taxa(VT)in the soil compartment and 7 VT in the root apparatus.We emphasized that the NGS analysis gives additional value to the results thanks to a more in-depth reading of the less represented AM fungus taxa.展开更多
Yield loss(Y_(Loss)) in the ratoon crop due to crushing damage to left stubble from mechanical harvesting of the main crop is a constraint for wide adoption of mechanized rice ratooning technology.Soil drying before t...Yield loss(Y_(Loss)) in the ratoon crop due to crushing damage to left stubble from mechanical harvesting of the main crop is a constraint for wide adoption of mechanized rice ratooning technology.Soil drying before the harvest of the main crop has been proposed to overcome this problem.The objective of this study was to determine the effect of soil drying during the mid-to-late grain filling stage of the main crop on grain yield of the ratoon crop in a mechanized rice ratooning system.Field experiments were conducted to compare Y_(Loss) between light(LD) and heavy(HD) soil drying treatments in Hubei province,central China in 2017 and 2018.Y_(Loss) was calculated as the percentage of yield reduction in the ratoon crop with the main crop harvested mechanically,relative to the grain yield of the ratoon crop with the main crop harvested manually.In comparison with LD,soil hardness was increased by 42.8%-84.7% in HD at the 5-20 cm soil depth at maturity of the main crop.Soil hardness at 5 and 10 cm depths reached respectively 4.05 and 7.07 kg cm^(-2) in HD.Soil drying treatment did not significantly affect the grain yield of the main crop.Under mechanical harvesting of the main crop,HD increased the grain yield of the ratoon crop by 9.4% relative to LD.Consequently,Y_(Loss) was only 3.4% in HD,in contrast to 16.3% in LD.The differences in grain yield and Y_(Loos) between the two soil drying treatments were explained mainly by panicles m^(-2),which was increased significantly by HD in the track zone of the ratoon crop compared with LD.These results suggest that heavy soil drying practice during the mid-to-late grain filling stage of the main crop is effective for reducing Y_(Loss) of the ratoon crop in a mechanized rice ratooning system.展开更多
Vitamin A palmitate (VAP) contains retinol and palmitic acid which is easily absorbed by body and widely used in skin care products. But, it is a hydrophobic and oxidation sensitive molecule which undergoes rapid degr...Vitamin A palmitate (VAP) contains retinol and palmitic acid which is easily absorbed by body and widely used in skin care products. But, it is a hydrophobic and oxidation sensitive molecule which undergoes rapid degradation especially in an aqueous environment. The purpose of this study was to prepare microcapsules of VAP using combination maltodextrin and modified starches. Emulsion of VAP was prepared using cremophore RH 40 with Tween 80 in a homogenizer and formed emulsion was spray-dried. The spray process was optimized using a central composite design for two variables to obtain microcapsules with desirable characteristics. Microcapsules containing 30% of VAP were produced using different concentration of wall materials. The prepared microcapsules were evaluated for their physical, morphological, in-vitro drug release and SEM study. The results showed that obtained microcapsules are nearly spherical in shape with a particle size ranged from 1 to 12 μm. The drug content and encapsulation efficiency (53% - 63%) of different batches were found within acceptable range. These stabilized drug loaded microcapsules were incorporated into silicone cream based formulation for convenient topical application and evaluated for its physicochemical parameters. The drug release study showed 80.18% to 83.43% of drug release from VAP microcapsules while topical formulations prepared by VAP microcapsules showed 67.09% to 71.45% drug release at the end of 24 hrs. The formulations were kept for 3 months stability study as per ICH guidelines and found to be stable.展开更多
The study evaluated the feasibility of using microwave enhanced hot air heating system for simultaneous dry blanching and dehydration of mushroom slices. The technology involves application of microwave energy at the ...The study evaluated the feasibility of using microwave enhanced hot air heating system for simultaneous dry blanching and dehydration of mushroom slices. The technology involves application of microwave energy at the beginning of dehydration process to inactivate enzymes as well as to remove a certain amount of moisture at the same time and then followed by hot air drying to complete the process. The study investigated effects of different processing parameters, i.e., microwave power level and exposure time on dehydration and quality characteristics of mushroom slices. Mushroom slices were pretreated with different microwave power levels of 240, 360 and 480 W for 1, 3 and 5 min before the hot air-drying. The optimum range of the microwave power level and pretreatment time was found to be 360 W, 3 min and 360 W, 1 min in obtaining the maximum and minimum levels of response parameters.展开更多
Biomass gasification is a well-developed technology with the potential to convert agricultural residues to value-added products. The availability of on-farm gasifiers that can handle low-density agricultural wastes su...Biomass gasification is a well-developed technology with the potential to convert agricultural residues to value-added products. The availability of on-farm gasifiers that can handle low-density agricultural wastes such as soybean residue, an underutilized feedstock, is limited. Therefore, the goal of this research was to install and assess an allothermal, externally heated, auger gasifier capable of converting agricultural wastes to combustible gas for on-farm grain drying. The system was used to convert soybean residues under different reactor temperature, i.e., 700°C, 750°C, 800°C, and 850°C. The results showed that increasing the reactor temperature from 700°C to 850°C increased the producer gas molar fractions of H2, CO, and CH4, from 1.1% to 1.5%, from 15.0% to 23.8%, and from 5.1% to 7.7%, respectively. The higher heating value of the producer gas reached 6.3 MJ/m3 at reactor temperature of 850°C. Specific gas yield increased from 0.32 to 0.58 m3/kgbiomass while char and particulate yield decreased from 41.7% to 33.6% by increasing the reactor temperature from 700°C to 850°C. Maximum carbon sequestration achieved, in the form of biochar-carbon, was 32% of the raw feedstock carbon. Gasification of collectable soybean residues from 1 acre would be sufficient to dry 1132 kg of soybean seeds (the average yield from one acre)展开更多
The feeding of coarse particles (>0.5 mm diameter) directly into a riser operating at positive pressure is important for drying and pre-heating applications. The presence of the feeding device can lead to heterogen...The feeding of coarse particles (>0.5 mm diameter) directly into a riser operating at positive pressure is important for drying and pre-heating applications. The presence of the feeding device can lead to heterogeneity of drying and heating, and is the main factor responsible for pressure loss in short conveying systems. However, there is a lack of information concerning the axial and radial distributions of coarse particles in this type of configuration, despite the recent advances when dealing with fine particles (FCC catalyst). The present work therefore investigates a vertical venturi feeder with the conveying system operating in dilute-phase regime with 1 mm spherical glass particles. Experimental assays revealed the behavior of the mass flow rate of solids in the system, and pressure measurements were made along the riser in order to evaluate the accuracy of simulations. Euler-Euler simulations provided close estimation of the experimental pressure drop and the pressure drop according to distance in the linear region. Simulation of the fluid dynamics in the riser showed that solids clusters were formed at low concentrations near the feeding device, reflecting heterogeneity in the solid phase volume fraction.展开更多
The significant demand for high quality food has motivated us to adopt appropriate processing methods to improve the food nutritional quality and flavors.In this study,the effects of five drying methods,namely,pulsed ...The significant demand for high quality food has motivated us to adopt appropriate processing methods to improve the food nutritional quality and flavors.In this study,the effects of five drying methods,namely,pulsed vacuum drying(PVD),freeze drying(FD),infrared drying(IRD),hot-air drying(HAD)and sun drying(SD)on free amino acids(FAAs),α-dicarbonyl compounds(α-DCs)and volatile compounds(VOCs)in rape bee pollen(RBP)were determined.The results showed that FD significantly released the essential amino acids(EAAs)compared with fresh samples while SD caused the highest loss.Glucosone was the dominantα-DCs in RBP and the highest loss was observed after PVD.Aldehydes were the dominant volatiles of RBP and SD samples contained more new volatile substances(especially aldehydes)than the other four drying methods.Comprehensively,FD and PVD would be potential methods to effectively reduce the quality deterioration of RBP in the drying process.展开更多
As an important factor that directly affects agricultural production, the social economy, and policy implementation,observed changes in dry/wet conditions have become a matter of widespread concern. However, previous ...As an important factor that directly affects agricultural production, the social economy, and policy implementation,observed changes in dry/wet conditions have become a matter of widespread concern. However, previous research has mainly focused on the long-term linear changes of dry/wet conditions, while the detection and evolution of the non-linear trends related to dry/wet changes have received less attention. The non-linear trends of the annual aridity index, obtained by the Ensemble Empirical Mode Decomposition(EEMD) method, reveal that changes in dry/wet conditions in China are asymmetric and can be characterized by contrasting features in both time and space in China. Spatially, most areas in western China have experienced transitions from drying to wetting, while opposite changes have occurred in most areas of eastern China. Temporally, the transitions occurred earlier in western China compared to eastern China. Research into the asymmetric spatial characteristics of dry/wet conditions compensates for the inadequacies of previous studies, which focused solely on temporal evolution;at the same time, it remedies the inadequacies of traditional research on linear trends over centennial timescales. Analyzing the non-linear trend also provides for a more comprehensive understanding of the drying/wetting changes in China.展开更多
This article presents system identification of wood drying process based on ARMAX model. Temperature and equivalent moisture content are considered as inputs, and moisture content of the wood sample during drying is t...This article presents system identification of wood drying process based on ARMAX model. Temperature and equivalent moisture content are considered as inputs, and moisture content of the wood sample during drying is taken as output of the system. The comparative study of RLS and FF-RLS to identify the system parameters is presented. Simulation results are presented to val-idate the efficacy of the ARMAX model for wood drying process.展开更多
Climate change may badly affect the availability of water and soil nutrients to rice plant. Research experiments were conducted at the Environmental Science Departmental field, Bangladesh Agricultural University, Myme...Climate change may badly affect the availability of water and soil nutrients to rice plant. Research experiments were conducted at the Environmental Science Departmental field, Bangladesh Agricultural University, Mymensingh during July 2017 to June 2019, to find out the suitable combination of biochar with inorganic fertilizers for minimizing seasonal yield scaled CH<sub>4</sub> emissions, reducing global warming potentials (GWPs) and sustainable rice farming under feasible irrigation practices. There were ten experimental treatments with different combinations of inorganic NPKS fertilizers and biochar (15 - 30 t/ha) under conventional flooding (CF) and alternate wetting-drying irrigations (AWDI). This study revealed that NPKS fertilization (50% of the recommended doze) with 15 t/ha biochar amendments under AWD irrigation maximized rice yield 6750 kg/ha and 4380 kg/ha in dry boro and wet aman seasons respectively, while the lowest rice yield 1850 kg/ha and 1550 kg/ha were recorded in continuously irrigated control treatment (T<sub>1</sub>) during the dry and wet seasons respectively. Seasonal cumulative CH<sub>4</sub> emission, yield scaled CH<sub>4 </sub>emission and GWPs were suppressed significantly with biochar amendments 15 - 30 t/ha under both conventional and AWDI irrigation systems during the wet and dry seasons of rice cultivation. Significant interactions were observed among biochar amendments and irrigation practices during the dry boro rice cultivation. Dry seasonal cumulative CH<sub>4</sub> emissions were decreased by 14.7%, 18.9% and 24.8% with biochar amendments at 15 t/ha, 20 t/ha and 30 t/ha respectively under conventional irrigation;while cumulative CH<sub>4</sub> emissions were reduced by 10.6%, 26% and 41.6% respectively, under AWDI system. Finally, total global warming potentials (GWPs) were decreased by 6% - 15%, 13% - 30% with biochar amendments under conventional and AWDI irrigations respectively, in wet season;while global warming potentials (GWPs) also decreased by 14% - 25%, 11% - 42% with biochar amendments under conventional and AWDI irrigations, respectively, in the dry boro season. Biochar amendments increased water productivity index to some extent, but AWD irrigations significantly increased water productivity over the conventional irrigation in both wet and dry seasons. After experimental period, it was found that soil porosity, redox status, soil organic carbon (SOC) as well as overall soil properties were improved significantly with biochar amendments and AWD irrigations. Conclusively, biochar amendments @15 - 20 t/ha with half of the recommended inorganic (NPKS) fertilizers under alternate wetting-drying irrigations revealed an environment friendly integrated package approach to reduce seasonal cumulative CH<sub>4</sub> emissions as well as GWPs, while improving rice rhizosphere environment and rice productivity to meet the national food security.展开更多
Experiments were conducted to evaluate the healing of drying cracks in air-dried bentonite-sand blocks after hydration and swelling in groundwater,providing justifications to simplify the protection of blocks prior to...Experiments were conducted to evaluate the healing of drying cracks in air-dried bentonite-sand blocks after hydration and swelling in groundwater,providing justifications to simplify the protection of blocks prior to installation in a high-level radioactive waste repository.Synthetic groundwater was prepared to represent the geochemistry of Beishan groundwater,and was used to hydrate the blocks during the swelling pressure and swelling strain measurements,as Beishan is the most promising site for China's repository.Healing of the surface cracks was recorded by photography,and healing of the internal cracks was visualized by CT images and hydraulic conductivity of air-dried blocks.The results indicate that the maximum swelling pressure and swelling strain are primarily affected by the geochemistry of Beishan groundwater,but not affected by the drying cracks.The maximum swelling pressure and swelling strain of air-dried blocks are comparable to or even higher than the pressure and strain of fresh blocks.The maximum swelling pressure measured in strong(i.e.high ion strength)Beishan groundwater was 44%of the pressure measured in deionized(DI)water,and the maximum swelling strain was reduced to 23%of the strain measured in DI water.Nevertheless,the remained swelling of the blocks hydrated in strong Beishan groundwater was sufficient to heal the surface and internal drying cracks,as demonstrated by the pictures of surface cracks and CT images.The hydraulic conductivity of the air-dried block permeated with strong groundwater was comparable(3.7×higher)to the hydraulic conductivity of the fresh block,indicating the self-healing of drying cracks after hydration and swelling in groundwater.A simplified method of protecting the block with plastic wraps before installation is recommended,since the remained swelling of the block hydrated in Beishan groundwater is sufficient to heal the drying cracks.展开更多
Lysine content is a criterion of the nutritional quality of rice.Understanding the process of lysine biosynthesis in early-flowering superior grain(SG)and late-flowering inferior grain(IG)of rice would advance breedin...Lysine content is a criterion of the nutritional quality of rice.Understanding the process of lysine biosynthesis in early-flowering superior grain(SG)and late-flowering inferior grain(IG)of rice would advance breeding and cultivation to improve nutritional quality.However,little information is available on differences in lysine anabolism between SG and IG and the underlying mechanism,and whether and how irrigation regimes affect lysine anabolism in these grains.A japonica rice cultivar was grown in the field and two irrigation regimes,continuous flooding(CF)and wetting alternating with partial drying(WAPD),were imposed from heading to the mature stage.Lysine content and activities of key enzymes of lysine biosynthesis,and levels of brassinosteroids(BRs)were lower in the IG than in the SG at the early grainfilling stage but higher at middle and late grain-filling stages.WAPD increased activities of these key enzymes,BR levels,and contents of lysine and total amino acids in IG,but not SG relative to CF.Application of 2,4-epibrassinolide to rice panicles in CF during early grain filling reproduced the effects of WAPD,but neither treatment altered the activities of enzymes responsible for lysine catabolism in either SG or IG.WAPD and elevated BR levels during grain filling increased lysine biosynthesis in IG.Improvement in lysine biosynthesis in rice should focus on IG.展开更多
Appropriate drying process with optimized controlling of drying parameters plays a vital role in the improvement of the quality and performance of propellant products.However,few research on solvent transport dynamics...Appropriate drying process with optimized controlling of drying parameters plays a vital role in the improvement of the quality and performance of propellant products.However,few research on solvent transport dynamics within NC-based propellants was reported,and its effect on the evolution of mechanical properties was not interpreted yet.This study is conducted to gain a comprehensive understanding of hot-air drying for NC-based propellants and clarify the effect of temperature on solvent transport behavior and further the change of mechanical properties during drying.The drying kinetic curves show the drying time required is decreased but the steady solvent content is increased and the drying rate is obviously increased with the increase of hot-air temperatures,indicating hot-air temperatures have a significant effect on drying kinetics.A modified drying model was established,and results show it is more appropriate to describe solvent transport behavior within NC-based propellants.Moreover,two linear equations were established to exhibit the relationship between solvent content and its effect on the change of tensile properties,and the decrease of residual solvent content causes an obvious increase of tensile strength and tensile modulus of propellant products,indicating its mechanical properties can be partly improved by adjustment of residual solvent content.The outcomes can be used to clarify solvent transport mechanisms and optimize drying process parameters of double-based gun propellants.展开更多
To investigate the influences of different admixtures on the drying shrinkage of polymer mortar in a metakaolin base,the experiments of VAE(vinyl acetate ethylene copolymer),APAM(anionic polyacrylamide)and CPAM(cation...To investigate the influences of different admixtures on the drying shrinkage of polymer mortar in a metakaolin base,the experiments of VAE(vinyl acetate ethylene copolymer),APAM(anionic polyacrylamide)and CPAM(cationic polyacrylamide)on the drying shrinkage properties of geopolymer mortar were designed under normal temperature curing conditions.An SP-175 mortar shrinkage dilatometer was introduced to measure the dry shrinkage of geopolymer mortar.Meanwhile,the drying shrinkage properties of geopolymer mortar are exhibited by the parameters of water loss rate,drying shrinkage rate,drying shrinkage strain and drying shrinkage coefficient.The experimental data are further fitted to obtain the prediction model of dry shrinkage of geopolymer mortar,which can better reflect the relationship between dry shrinkage rate and time.Finally,the experimental results demonstrate that the dry shrinkage of geopolymer mortar can be significantly increased by adding 4%VAE admixture,meanwhile under the condition that the polymer film formed by VAE reaction can strengthen and toughen the mortar.2.5%APAM admixture and 1.5%CPAM admixture can enhance the dry shrinkage performance of geopolymer mortar in a certain range.展开更多
文摘The paper bulids a countercurrent multi-effect drying process model which can be expressed as a linear programming(LP) problem with the minimum total energy consumption as target function. Based on the model it can be conventient to solve the heat load , degree of drying and other drying parameters of each effect. And it realizes the mathematical simulation an analysis of multi-effect drying process. Such process not only reuses the secondary steam but also utilizes the high energy grade. Drying silica sand using 1-effect drying to 5-effect drying is presented as an example. The energy consumption and energy saving rate are compared by using co-current multi-effect drying and countercurrent multi-effect drying. As a summary, the countercurrent multi-effect drying is better than co-current drying. Considered the equipment investment and energy conservation, the study also concluded that the countercurrent 4-effect drying is the optimum selection, and it can save 57.6% energy compared to countercurrent 1-effect drying.
文摘Artificial neural network has unique advantages for massively parallel processing, distributed storage capacity and self-learning ability. The paper mainly constructs neural network identifier and neural network controller for system identification and control on temperature and hmnidity of heating and drying system of materials. And the paper introduces the structure and principles of neural network, and focuses on analyzing learning algorithm, training algorithm and limitation of the most widely applied multi-layer feed-forward neural network （ BP network） , based on which the paper proposes introducing momentum to improve BP network.
文摘Solar drying systems are becoming a popular alternative to traditional energy-based drying systems for agricultural products due to their effectiveness and reduced fuel consumption.Although the efficiency of solar drying systems has been thoroughly investigated,their sustainability has not been studied enough.This study aims to fill that gap by conducting a life-cycle assessment of two new solar drying systems built in Udaipur,Rajasthan,India.The environmental implications of an innovative cylindrical solar-assisted drying system and a phase-change material-based solar drying system were evaluated using cradle-to-gate life-cycle analysis.The study uses the ReCiPe 2016 endpoints(H)technique to calculate various aspects such as midpoint,endpoint,single score,normalization result,and network diagram for phase-change material-based solar drying and cylindrical solar-assisted drying.Results show that phase-change material-based solar drying has an average of 40%more impact on the environment than cylindrical solar-assisted drying,with a high impact found in human non-carcinogenic toxicity,mainly due to the production of phase-change materials.However,cylindrical solar-assisted drying system crossover phase-change material based solar drying in terms of its impact on human carcinogenic toxicity and fossil resource scarcity.The contribution to global warming of phase-change material-based solar drying is 13.7%more than that of cylindrical solar-assisted drying.The endpoint characterization indicates that phase-change material-based solar drying exceeds in terms of human health(40%)and ecosystem(37.04%),whereas cylindrical solar-assisted drying surpasses phase-change material-based solar drying in terms of impacts on resources,at 14%.The early drying in phase-change material-based solar drying makes up for its higher impact than that in cylindrical solar-assisted drying,which takes 3 hours longer to dry.This study offers guidance and methods for making the best choice of solar-powered dryers.
文摘Côte d’Ivoire has been the world’s leading producer of cocoa beans for several decades. Apart from this production performance, the quality of the beans, which are mainly exported to the major chocolate-making countries, presents a quality problem to the point of suffering a discount on the international market. One of these quality problems is the content of ochratoxin A, a mycotoxin produced by fungi. Finally, to verify the level of contamination in beans produced in Côte d’Ivoire, a study was carried out. It consisted of collecting information on fermentation and drying times (The two major post-harvest operations) and collecting beans, which were analyzed by electrophoresis using the High Performance Liquid Chromatography (HPLC) method. The results obtained show ochratoxin A contents of between 0.05 µg/kg and 0.17 µg/kg. The general level of contamination is therefore very low and below the tolerable limit which is 2 µg/kg. In addition, the correlative study between the fermentation and drying times of the beans revealed no significant influence (p < 0.01) of the duration of these operations on the level of ochratoxin A contamination. Major contamination can occur after post-harvest activities carried out by producers. This is certainly due to the development of fungi responsible for the production of ochratoxin A during the period of storage and marketing of cocoa beans in conditions of high humidity in storage enclosures. Producers need to be made more aware of the need to ensure that cocoa beans are properly dried and stored in dry areas to avoid moisture build-up, which is a source of mould growth and ochratoxin A production.
文摘The effect of a storage system on drying time and estimation of drying parameters of cocoa beans using an indirect solar dryer with a sensible heat energy storage system (stones which act as both absorber and heat storage media) is the main subject of this article. This dryer, which uses stones as storage material and is made of wood and plywood, was used to dry a quantity of 5 kg of fermented cocoa beans. The drying parameters for the drying curves and the drying efficiency of cocoa beans were established and studied. The drying curves were modelled from semi-empirical models. The results showed that the moisture of cocoa beans decreased from 60% to 7% in wet basis. With a solar collector and drying efficiency of 40% and 34%, respectively. And this with a maximum average difference temperature between the drying air and the ambient temperature of 13.25˚C day or night. The best concordances are obtained with R2 values of 0.9983, 0.9843, 0.9813 and 0.9837 respectively from the models of Hii, Jena and Das, Demir et al. and Alibas.
基金the National Key Research and Development Program of China(2022YFD1500705)National Natural Science Foundation of China(U19A2035)for financial support。
文摘Strip-till(ST),including straw mulching in the inter-row and localized fertilization in the intra-row,is a conservation tillage system for improving soil quality and crop growth.However,the yield advantage of maize under ST compared to conventional tillage(CT)remains unstable,and the strategies to increase maize yield under ST are unclear.This study aims to understand the physiological mechanism underlining maize yield formation under ST by comparing two maize cultivars,DKM753 and DK517,with contrasting yield performance in ST versus CT systems.Compared to CT,ST resulted in a 4.5%yield increase for DKM753 but a 5.6%decrease for DK517.These yield differences were primarily attributed to variations in grain number per ear(GN).During the rapid growth stage(V14-R3),i.e.,two weeks before and after silking,DKM753 showed a 6.7%increase in maximum growth rate(V_(max))and a 6.3%increase in average growth rate(V)under ST,whereas DK517 exhibited decline of 8.5%in V_(max) and 12.3%in V.Significant positive correlations are observed between V_(max) and V with GN under ST(R^(2)=0.79 and R^(2)=0.90,respectively).Enhanced dry matter accumulation in DKM753 under ST was attributed to increased leaf expansion rates,contributing to a larger photosynthate source.The straw mulching and localized nitrogen fertilization increased root-zone nitrogen availability at silking in ST compared to CT.DKM753 had a greater root system which made better use of the soil N and lead to an increased leaf nitrogen accumulation by 14.9%under ST.It is concluded that maize yield under the strip-till system is determined by grain number per ear,which can be increased by increasing nitrogen accumulation,plant growth,and ear development around silking stage.A sound root system can efficiently utilize soil nitrogen resources under the strip-till system,increasing plant nitrogen accumulation and thereby promoting plant growth.
基金AGER-Fondazioni in rete per la ricerca agroalimentare(https://www.progettoager.it/)(Grant No.2010-2369)by Joint Programming Initiative on Agriculture,Food Security and Climate Change(FACCE-JPI)project Green Rice(Sustainable and environmental friendly rice cultivation systems in Europe).
文摘Alternate wetting and drying(AWD)system,in which water has been reduced by approximately 35%with an increased occurrence of beneficial arbuscular mycorrhizal(AM)symbiosis and no negative impact on rice yield,was proposed to utilize water and nutrients more sustainable.In this study,we selected six rice cultivars(Centauro,Loto,Selenio,Vialone nano,JSendra and Puntal)grown under AWD conditions,and investigated their responsiveness to AM colonization and how they select diverse AM taxa.In order to investigate root-associated AM fungus communities,molecular cloning-Sanger sequencing on small subunit rDNA data were obtained from five out of the six rice cultivars and compared with Next Generation Sequencing(NGS)data,which were previously obtained in Vialone nano.The results showed that all the cultivars were responsive to AM colonization with the development of AM symbiotic structures,even if with differences in the colonization and arbuscule abundance in the root systems.We identified 16 virtual taxa(VT)in the soil compartment and 7 VT in the root apparatus.We emphasized that the NGS analysis gives additional value to the results thanks to a more in-depth reading of the less represented AM fungus taxa.
基金supported by the Major International (Regional)Joint Research Project of National Natural Science Foundation of China (32061143038)the China Agriculture Research System(CARS-01-20)the Fundamental Research Funds for the Central Universities (2662020ZKPY015)。
文摘Yield loss(Y_(Loss)) in the ratoon crop due to crushing damage to left stubble from mechanical harvesting of the main crop is a constraint for wide adoption of mechanized rice ratooning technology.Soil drying before the harvest of the main crop has been proposed to overcome this problem.The objective of this study was to determine the effect of soil drying during the mid-to-late grain filling stage of the main crop on grain yield of the ratoon crop in a mechanized rice ratooning system.Field experiments were conducted to compare Y_(Loss) between light(LD) and heavy(HD) soil drying treatments in Hubei province,central China in 2017 and 2018.Y_(Loss) was calculated as the percentage of yield reduction in the ratoon crop with the main crop harvested mechanically,relative to the grain yield of the ratoon crop with the main crop harvested manually.In comparison with LD,soil hardness was increased by 42.8%-84.7% in HD at the 5-20 cm soil depth at maturity of the main crop.Soil hardness at 5 and 10 cm depths reached respectively 4.05 and 7.07 kg cm^(-2) in HD.Soil drying treatment did not significantly affect the grain yield of the main crop.Under mechanical harvesting of the main crop,HD increased the grain yield of the ratoon crop by 9.4% relative to LD.Consequently,Y_(Loss) was only 3.4% in HD,in contrast to 16.3% in LD.The differences in grain yield and Y_(Loos) between the two soil drying treatments were explained mainly by panicles m^(-2),which was increased significantly by HD in the track zone of the ratoon crop compared with LD.These results suggest that heavy soil drying practice during the mid-to-late grain filling stage of the main crop is effective for reducing Y_(Loss) of the ratoon crop in a mechanized rice ratooning system.
文摘Vitamin A palmitate (VAP) contains retinol and palmitic acid which is easily absorbed by body and widely used in skin care products. But, it is a hydrophobic and oxidation sensitive molecule which undergoes rapid degradation especially in an aqueous environment. The purpose of this study was to prepare microcapsules of VAP using combination maltodextrin and modified starches. Emulsion of VAP was prepared using cremophore RH 40 with Tween 80 in a homogenizer and formed emulsion was spray-dried. The spray process was optimized using a central composite design for two variables to obtain microcapsules with desirable characteristics. Microcapsules containing 30% of VAP were produced using different concentration of wall materials. The prepared microcapsules were evaluated for their physical, morphological, in-vitro drug release and SEM study. The results showed that obtained microcapsules are nearly spherical in shape with a particle size ranged from 1 to 12 μm. The drug content and encapsulation efficiency (53% - 63%) of different batches were found within acceptable range. These stabilized drug loaded microcapsules were incorporated into silicone cream based formulation for convenient topical application and evaluated for its physicochemical parameters. The drug release study showed 80.18% to 83.43% of drug release from VAP microcapsules while topical formulations prepared by VAP microcapsules showed 67.09% to 71.45% drug release at the end of 24 hrs. The formulations were kept for 3 months stability study as per ICH guidelines and found to be stable.
文摘The study evaluated the feasibility of using microwave enhanced hot air heating system for simultaneous dry blanching and dehydration of mushroom slices. The technology involves application of microwave energy at the beginning of dehydration process to inactivate enzymes as well as to remove a certain amount of moisture at the same time and then followed by hot air drying to complete the process. The study investigated effects of different processing parameters, i.e., microwave power level and exposure time on dehydration and quality characteristics of mushroom slices. Mushroom slices were pretreated with different microwave power levels of 240, 360 and 480 W for 1, 3 and 5 min before the hot air-drying. The optimum range of the microwave power level and pretreatment time was found to be 360 W, 3 min and 360 W, 1 min in obtaining the maximum and minimum levels of response parameters.
文摘Biomass gasification is a well-developed technology with the potential to convert agricultural residues to value-added products. The availability of on-farm gasifiers that can handle low-density agricultural wastes such as soybean residue, an underutilized feedstock, is limited. Therefore, the goal of this research was to install and assess an allothermal, externally heated, auger gasifier capable of converting agricultural wastes to combustible gas for on-farm grain drying. The system was used to convert soybean residues under different reactor temperature, i.e., 700°C, 750°C, 800°C, and 850°C. The results showed that increasing the reactor temperature from 700°C to 850°C increased the producer gas molar fractions of H2, CO, and CH4, from 1.1% to 1.5%, from 15.0% to 23.8%, and from 5.1% to 7.7%, respectively. The higher heating value of the producer gas reached 6.3 MJ/m3 at reactor temperature of 850°C. Specific gas yield increased from 0.32 to 0.58 m3/kgbiomass while char and particulate yield decreased from 41.7% to 33.6% by increasing the reactor temperature from 700°C to 850°C. Maximum carbon sequestration achieved, in the form of biochar-carbon, was 32% of the raw feedstock carbon. Gasification of collectable soybean residues from 1 acre would be sufficient to dry 1132 kg of soybean seeds (the average yield from one acre)
文摘The feeding of coarse particles (>0.5 mm diameter) directly into a riser operating at positive pressure is important for drying and pre-heating applications. The presence of the feeding device can lead to heterogeneity of drying and heating, and is the main factor responsible for pressure loss in short conveying systems. However, there is a lack of information concerning the axial and radial distributions of coarse particles in this type of configuration, despite the recent advances when dealing with fine particles (FCC catalyst). The present work therefore investigates a vertical venturi feeder with the conveying system operating in dilute-phase regime with 1 mm spherical glass particles. Experimental assays revealed the behavior of the mass flow rate of solids in the system, and pressure measurements were made along the riser in order to evaluate the accuracy of simulations. Euler-Euler simulations provided close estimation of the experimental pressure drop and the pressure drop according to distance in the linear region. Simulation of the fluid dynamics in the riser showed that solids clusters were formed at low concentrations near the feeding device, reflecting heterogeneity in the solid phase volume fraction.
基金supported by National Natural Science Foundation of China(Nos.31871861 and 31501548)The Apicultural Industry Technology System(NCYTI-43-KXJ17)The Science and Technology Innovation Project of Chinese Academy of Agricultural Sciences(CAAS-ASTIP-2015-IAR)。
文摘The significant demand for high quality food has motivated us to adopt appropriate processing methods to improve the food nutritional quality and flavors.In this study,the effects of five drying methods,namely,pulsed vacuum drying(PVD),freeze drying(FD),infrared drying(IRD),hot-air drying(HAD)and sun drying(SD)on free amino acids(FAAs),α-dicarbonyl compounds(α-DCs)and volatile compounds(VOCs)in rape bee pollen(RBP)were determined.The results showed that FD significantly released the essential amino acids(EAAs)compared with fresh samples while SD caused the highest loss.Glucosone was the dominantα-DCs in RBP and the highest loss was observed after PVD.Aldehydes were the dominant volatiles of RBP and SD samples contained more new volatile substances(especially aldehydes)than the other four drying methods.Comprehensively,FD and PVD would be potential methods to effectively reduce the quality deterioration of RBP in the drying process.
基金supported by the National key research and development program (2019YFA0607104)National Natural Science Foundation of China (Grant Nos. 41991231, 42275034, 41975076, 42075029, 42075017, and 42075018)the Gansu Provincial Science and Technology Project (22JR5RA405)。
文摘As an important factor that directly affects agricultural production, the social economy, and policy implementation,observed changes in dry/wet conditions have become a matter of widespread concern. However, previous research has mainly focused on the long-term linear changes of dry/wet conditions, while the detection and evolution of the non-linear trends related to dry/wet changes have received less attention. The non-linear trends of the annual aridity index, obtained by the Ensemble Empirical Mode Decomposition(EEMD) method, reveal that changes in dry/wet conditions in China are asymmetric and can be characterized by contrasting features in both time and space in China. Spatially, most areas in western China have experienced transitions from drying to wetting, while opposite changes have occurred in most areas of eastern China. Temporally, the transitions occurred earlier in western China compared to eastern China. Research into the asymmetric spatial characteristics of dry/wet conditions compensates for the inadequacies of previous studies, which focused solely on temporal evolution;at the same time, it remedies the inadequacies of traditional research on linear trends over centennial timescales. Analyzing the non-linear trend also provides for a more comprehensive understanding of the drying/wetting changes in China.
文摘This article presents system identification of wood drying process based on ARMAX model. Temperature and equivalent moisture content are considered as inputs, and moisture content of the wood sample during drying is taken as output of the system. The comparative study of RLS and FF-RLS to identify the system parameters is presented. Simulation results are presented to val-idate the efficacy of the ARMAX model for wood drying process.
文摘Climate change may badly affect the availability of water and soil nutrients to rice plant. Research experiments were conducted at the Environmental Science Departmental field, Bangladesh Agricultural University, Mymensingh during July 2017 to June 2019, to find out the suitable combination of biochar with inorganic fertilizers for minimizing seasonal yield scaled CH<sub>4</sub> emissions, reducing global warming potentials (GWPs) and sustainable rice farming under feasible irrigation practices. There were ten experimental treatments with different combinations of inorganic NPKS fertilizers and biochar (15 - 30 t/ha) under conventional flooding (CF) and alternate wetting-drying irrigations (AWDI). This study revealed that NPKS fertilization (50% of the recommended doze) with 15 t/ha biochar amendments under AWD irrigation maximized rice yield 6750 kg/ha and 4380 kg/ha in dry boro and wet aman seasons respectively, while the lowest rice yield 1850 kg/ha and 1550 kg/ha were recorded in continuously irrigated control treatment (T<sub>1</sub>) during the dry and wet seasons respectively. Seasonal cumulative CH<sub>4</sub> emission, yield scaled CH<sub>4 </sub>emission and GWPs were suppressed significantly with biochar amendments 15 - 30 t/ha under both conventional and AWDI irrigation systems during the wet and dry seasons of rice cultivation. Significant interactions were observed among biochar amendments and irrigation practices during the dry boro rice cultivation. Dry seasonal cumulative CH<sub>4</sub> emissions were decreased by 14.7%, 18.9% and 24.8% with biochar amendments at 15 t/ha, 20 t/ha and 30 t/ha respectively under conventional irrigation;while cumulative CH<sub>4</sub> emissions were reduced by 10.6%, 26% and 41.6% respectively, under AWDI system. Finally, total global warming potentials (GWPs) were decreased by 6% - 15%, 13% - 30% with biochar amendments under conventional and AWDI irrigations respectively, in wet season;while global warming potentials (GWPs) also decreased by 14% - 25%, 11% - 42% with biochar amendments under conventional and AWDI irrigations, respectively, in the dry boro season. Biochar amendments increased water productivity index to some extent, but AWD irrigations significantly increased water productivity over the conventional irrigation in both wet and dry seasons. After experimental period, it was found that soil porosity, redox status, soil organic carbon (SOC) as well as overall soil properties were improved significantly with biochar amendments and AWD irrigations. Conclusively, biochar amendments @15 - 20 t/ha with half of the recommended inorganic (NPKS) fertilizers under alternate wetting-drying irrigations revealed an environment friendly integrated package approach to reduce seasonal cumulative CH<sub>4</sub> emissions as well as GWPs, while improving rice rhizosphere environment and rice productivity to meet the national food security.
基金supported by the National Natural Science Foundation of China(Grant No.41972265)the Fundamental Research Funds for the Central Universities(Grant No.lzujbky-2021-57)+1 种基金the Gansu Province Science Foundation(Grant No.20JR10RA492)Special thanks to the Environmental Research and Education Foundation for supporting the first author(Y.Tan)through a fellowship for his study at the University of Wisconsin-Madison.
文摘Experiments were conducted to evaluate the healing of drying cracks in air-dried bentonite-sand blocks after hydration and swelling in groundwater,providing justifications to simplify the protection of blocks prior to installation in a high-level radioactive waste repository.Synthetic groundwater was prepared to represent the geochemistry of Beishan groundwater,and was used to hydrate the blocks during the swelling pressure and swelling strain measurements,as Beishan is the most promising site for China's repository.Healing of the surface cracks was recorded by photography,and healing of the internal cracks was visualized by CT images and hydraulic conductivity of air-dried blocks.The results indicate that the maximum swelling pressure and swelling strain are primarily affected by the geochemistry of Beishan groundwater,but not affected by the drying cracks.The maximum swelling pressure and swelling strain of air-dried blocks are comparable to or even higher than the pressure and strain of fresh blocks.The maximum swelling pressure measured in strong(i.e.high ion strength)Beishan groundwater was 44%of the pressure measured in deionized(DI)water,and the maximum swelling strain was reduced to 23%of the strain measured in DI water.Nevertheless,the remained swelling of the blocks hydrated in strong Beishan groundwater was sufficient to heal the surface and internal drying cracks,as demonstrated by the pictures of surface cracks and CT images.The hydraulic conductivity of the air-dried block permeated with strong groundwater was comparable(3.7×higher)to the hydraulic conductivity of the fresh block,indicating the self-healing of drying cracks after hydration and swelling in groundwater.A simplified method of protecting the block with plastic wraps before installation is recommended,since the remained swelling of the block hydrated in Beishan groundwater is sufficient to heal the drying cracks.
基金This work was supported by the National Natural Science Foundation of China(32071943,32272198).
文摘Lysine content is a criterion of the nutritional quality of rice.Understanding the process of lysine biosynthesis in early-flowering superior grain(SG)and late-flowering inferior grain(IG)of rice would advance breeding and cultivation to improve nutritional quality.However,little information is available on differences in lysine anabolism between SG and IG and the underlying mechanism,and whether and how irrigation regimes affect lysine anabolism in these grains.A japonica rice cultivar was grown in the field and two irrigation regimes,continuous flooding(CF)and wetting alternating with partial drying(WAPD),were imposed from heading to the mature stage.Lysine content and activities of key enzymes of lysine biosynthesis,and levels of brassinosteroids(BRs)were lower in the IG than in the SG at the early grainfilling stage but higher at middle and late grain-filling stages.WAPD increased activities of these key enzymes,BR levels,and contents of lysine and total amino acids in IG,but not SG relative to CF.Application of 2,4-epibrassinolide to rice panicles in CF during early grain filling reproduced the effects of WAPD,but neither treatment altered the activities of enzymes responsible for lysine catabolism in either SG or IG.WAPD and elevated BR levels during grain filling increased lysine biosynthesis in IG.Improvement in lysine biosynthesis in rice should focus on IG.
基金the National Natural Science Foundation of China(Grant No.22075146).
文摘Appropriate drying process with optimized controlling of drying parameters plays a vital role in the improvement of the quality and performance of propellant products.However,few research on solvent transport dynamics within NC-based propellants was reported,and its effect on the evolution of mechanical properties was not interpreted yet.This study is conducted to gain a comprehensive understanding of hot-air drying for NC-based propellants and clarify the effect of temperature on solvent transport behavior and further the change of mechanical properties during drying.The drying kinetic curves show the drying time required is decreased but the steady solvent content is increased and the drying rate is obviously increased with the increase of hot-air temperatures,indicating hot-air temperatures have a significant effect on drying kinetics.A modified drying model was established,and results show it is more appropriate to describe solvent transport behavior within NC-based propellants.Moreover,two linear equations were established to exhibit the relationship between solvent content and its effect on the change of tensile properties,and the decrease of residual solvent content causes an obvious increase of tensile strength and tensile modulus of propellant products,indicating its mechanical properties can be partly improved by adjustment of residual solvent content.The outcomes can be used to clarify solvent transport mechanisms and optimize drying process parameters of double-based gun propellants.
基金Funded by the the Shaanxi Provincial Natural Science Basic Research Plan(No.2021JQ-471)the Natural Science Project of Shaanxi Provincial Department of Education(No.21JK0802)。
文摘To investigate the influences of different admixtures on the drying shrinkage of polymer mortar in a metakaolin base,the experiments of VAE(vinyl acetate ethylene copolymer),APAM(anionic polyacrylamide)and CPAM(cationic polyacrylamide)on the drying shrinkage properties of geopolymer mortar were designed under normal temperature curing conditions.An SP-175 mortar shrinkage dilatometer was introduced to measure the dry shrinkage of geopolymer mortar.Meanwhile,the drying shrinkage properties of geopolymer mortar are exhibited by the parameters of water loss rate,drying shrinkage rate,drying shrinkage strain and drying shrinkage coefficient.The experimental data are further fitted to obtain the prediction model of dry shrinkage of geopolymer mortar,which can better reflect the relationship between dry shrinkage rate and time.Finally,the experimental results demonstrate that the dry shrinkage of geopolymer mortar can be significantly increased by adding 4%VAE admixture,meanwhile under the condition that the polymer film formed by VAE reaction can strengthen and toughen the mortar.2.5%APAM admixture and 1.5%CPAM admixture can enhance the dry shrinkage performance of geopolymer mortar in a certain range.
